There may be a case when you switch “ON” the hot heater connection, but the heater indicator won’t light. If the flame is blue then it indicated that all the air has completely been disposed of, solving your issue. Best RV Mattress Short Queen 2021 | Top 10 Picks for RVers, Top 8 Best RV Tire Pressure Monitoring System (TPMS) Reviews, The 10 Best 4-Person Tents For Camping In 2021. However, some people using the Suburban RV hot water heater have run into the problem that it ⦠The flange securing the burner heat exchanger tube to the internal front fascia of the appliance may not be properly formed. In the end, it all machinery, and is likely to wary out with time or owing to an internal malfunction. Having access to hot water in a chilled environment can be extremely useful. Read on to what could have gone wrong and the corresponding Suburban RV hot water heater troubleshooting. Video 04: Sediment Removal. If the current is not supplying between 13 to 15 volts to the heater then this is the problem. If soot is present, immediately shut the water heater down and contact your dealer or an authorised service person. Recreational Vehicles or also most commonly known as RVs are designed to be taken out on trips or camping. Suburban in hot water over licence suspension. This is used to start up the flame for your heater. In case, the hot heater starts, you could conclude that air entrance is causing the real issue. What are the defects? Tel (626) 543-2500 Fax (626) 331-4848 A common issue with a Suburban hot water system installed in a caravan, is that it won't run on gas. Most people also bring equipment with them so that they can enjoy their trip to the fullest. Outdoorfact.com is a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for sites to earn advertising fees by advertising and linking to Amazon.com. These can be used to heat up the water for your use when you are in cold areas. The picture looks perfect, but what if your Suburban RV hot water heater won’t light? Tel (626) 543-2500 Fax (626) 331-4848 Hot water heats up on gas and electricity to proper temp, tested by relief valve. Best RV Cover Reviews For RVers: Do NOT Buy Before Reading This! © 2021 - Outdoor Fact. Posted By: bluwtr49 on 08/31/09 07:15am Recently our Suburban hot water heater has had a bit of a problem while running on propane. These are quality units, but problems can occur. Monitor the ACCCâs Product Safety Australia website for official recall notices www.productsafety.gov.au RV Hot Water Electrical Repair â Bad Switch. If this ignitor becomes damaged or faulty then your heater will be unable to start up. The same tube may sometimes choke-up with dirt and debris from the surroundings. Suburban 520900 Water Heater Element with Gasket for SW-Series - 120V. The water will drain out when you remove the anode. Recent SUBURBAN MANUFACTURING Water Heater questions, problems & answers. The inside switch, on the control panel, next to the reset light, does nothing. Install a carbon monoxide alarm in all caravans and motorhomes that have been inspected, tested and passed. I have a SW12DE Suburban hot water heater, in a 2010 Forest River 5th wheel. Turn off your hot water system 2. The smell and taste of your water can be affected by many things including;- ⢠Water left in tanks in the hot sun ⢠Using a garden hose to fill tanks ⢠Using inferior grade water hoses to fill tanks ⢠Filling tanks with brackish or bore water ⢠Leaving water in tanks for prolonged period of times ⢠Accidentally getting fuel or other contaminants in the tanks We often get asked if there is anything that can be done about removing taste and smell from water tanks, ⦠Itâs normal to hear steam-like noises coming from your water heater as it heats ⦠The Australian Gas Association, the body responsible for the certification of gas appliances sold in Australia, has suspended the gas licence for a range of Suburban gas/electric hot water systems. If the pilot light is on, there could be a problem with the thermocouple. Another reason for your heater to not light up can be that the voltage it is receiving from the RV is really unstable. Keep them alive for 15 to 20 seconds and this should be enough to completely purge the air in your system. Get it as soon as Tue, Feb 16. I first noticed it when I was sitting outside and it attempeted to light and I heard the igniter clicking like crazy and then stopped. Steer Safe Review 2021: Is It Worth The Price? A wiring diagram is a simplified conventional pictorial representation of an electric circuit. You have entered an incorrect email address! Exercise care. If your home has no one but you around, the mentioned solutions could help you big time. This usually lets the air bleed out fixing the problem. It may not be recognizing that the pilot light is on and therefore will not ignite the gas. But Considering this, water heaters are a great option. During use on gas, hot water services with the defect may emit carbon monoxide into the caravan or motor home. Authorities are urging RV owners to check their hot water services, following the recall of Suburban RV Hot Water Services sold between April 2018 and September 2019. 2) Turn off the gas supply at the bottle. Hot Water Problem #5: Your hot water system makes strange noises. pressure relief valve. Unsubscribe at any time. This causes the flame to die out if it does light up or sometimes the flame does not light up at all. hi all. Assortment of suburban water heater wiring diagram. I am having problems with it working on gas. CamperUpgrade.com is a participant of the Amazon Services LLC Associates Program, an affiliate advertising program – it is designed to provide an aid for the websites in earning an advertisement fee – by means of advertising and linking to Amazon.com products. This can be extremely annoying for people. Bangs, pops and gurgling sounds can be caused simply by the expanding and contracting of metal parts. In fact, the safety notices refer to units manufactured between April 4, 2018 to August 1, 2019 - over a whole year's production. SUBURBAN WATER HEATER GENERAL MAINTENANCE VIDEO SERIES Video 01: Anode Rod Function and Replacement. We won't send you spam. If this is not possible, then the travel of the door must be restricted ECON Travel Trailer Review 2021- Is It Good? If hot water is released, you could be scalded. Free expert DIY tips, support, troubleshooting help & repair advice for all SUBURBAN MANUFACTURING Water Heater products. These are common failures after a few years use and can require replacing. Hi members Have a suburban hws sw6dea in my caravan.Rang up New Age gold coast to try to find out what is going on with these hws.They dont know what the problem is but they are having a meeting to-morrow to discuss this problem.Never have read the service manual,but to-day i read it under the maintenance section that your water system should be operated at least twice a week ⦠Remember to undergo the practice at least twice in a year for ensuring effective heater functioning. Sometimes, one misses seeing the simple things that may be causing the RV water heater from lighting. To detect whether it is the air causing the problem, light the stove burners, and consequently switch on the RV water heater. 4.8 out of 5 stars 894. The best thing would be to blow out the chamber partition as well, for ensuring effective cleaning. 3 Ways To Fix Suburban RV Hot Water Heater Won’t Light, 3 Ways To Prepare For Camping With A 2 Year Old Kid, 3 Common Mr. Heater Pilot Light Problems (Troubleshooting), 3 Ways To Fix Coleman Catalytic Heater Wick, 3 Common AeroBed Deflate Problems (Troubleshooting), 3 Common Roadtrek Battery Problems (Troubleshooting), 4 Ways To Fix Carefree Electric Awning Problem, 3 Ways To Fix Refrigerator Thermistor Problem. Carlos Perry’s passion for outdoor activities can be traced back to 5 years ago when he spent a significant time to conquer beautiful pristine lands and experience different cultures with his best friends. User manuals, Suburban Water Heater Operating guides and Service manuals. 3 year old caravan we live in 24/7. 1325 N. Grand Avenue, Suite 100, Covina, CA 91724. 1325 N. Grand Avenue, Suite 100, Covina, CA 91724. 3 Common RV Solenoid Problems (Troubleshooting). Posted By: bluwtr49 on 08/31/09 07:15am Recently our Suburban hot water heater has had a bit of a problem while running on propane. As of Friday, there had been no official update from the Australian Gas Association (AGA), only that tests were continuing in order to determine if more than a single hot water system was involved. If a BSP threaded anode rod is fitted into a Suburban HWS it will do irreversible damage to the pitch on the internal thread of the tank and cause future leaks. When you consider the Suburban units involved are the most commonly used hot water systems installed in Australian caravans and motorhomes, there could be hundreds, possibly thousands of RVs involved. If air manages to enter the LP or the liquid propane lines, it becomes a hindrance to the water heater, and it won’t light. If you have a dual mode (gas and electric) hot water system, and it works on gas but not in the electric mode, the heating element could be broken. This document doesnât ⦠The blocked passage hinders propane from getting to the igniter. If this does not bleed the air out completely then it is advised that you light up the burners on your stove. If no, then reading on, could help you survive in secluded places. What are the hazards? If this has also happened to you then here a few ways you can troubleshoot. Gas valve – this is located on the exterior panel of the hot water system, and contains the solenoid that allows gas to flow. With city water flowing, or the pump pumping water, when the water heater is full, water will come out of the relief valve. These ensure that the user has access to a bed, kitchen, and washroom even when they are enjoying their outdoor trips. There are three main causes: Gas supply issue; Electrical issue; Gas valve issue; Check your other gas appliances like your stove and fridge and ensure they are running properly. Suburban RV Hot Water Heater Won’t Light: Causes And Solutions, 8 Worst Travel Trailer Brands to Avoid Today [2021 Update], Best Travel Trailer & RV Brands 2021 – Top Rated Manufacturers, Top 10 Best Class C RV Brands For The Money, The Cheapest State to Buy RV: Evading Sales Tax and Other Fees, A Breakdown of Living in an RV Full Time Cost, How To Read Colt Serial Numbers For First-timers. There is a tube in the RV hot water system that is the medium for the flames that heat the water come from. 1) Switch of the HWS and disconnect 240 volt power to the caravan. Home is where you park your RV! Traveling is a passion that can lead people to unknown places! If you have no hot water the first thing you need to do is check to see if you have gas flow and if the pilot light is on. By the time it gets to the outlets, it's luke warm. This could be due to a poor connection between the electric PC board and the plug. Free up any other electrical sockets that you might be using so that your heater can get more current and start-up. The light used to come on, when you put the switch to the on position, but now nothing. Porcelain lining. The water heaters have up-front controls and push-button lighting. Here is how you can fix: To detect whether it is the air causing the problem, light the stove burners, and consequently switch on the RV water heater. Interstate AGM Battery Review 2021- Worth It? These are relatively small problems, and only need a part replaced. Solution: You could make use of compressed air to blow out the tube so that all the impurities force out with pressure. Chances are if youâve run into a problem with a different type of water heater it has ⦠If possible, do not install the water heater to where the vent can be covered or obstructed when any door on the trailer is opened. This is a quick fix but you will have to get the ignitor replaced with a new one once you get back from your trip. These are quality units, but problems can occur. This little problem is driving me nuts. Maybe, things work out this time. Common part numbers for this model are SW6DEA and SW6DA. There could be possible chances of a spider entering the tube system too. Most other parts of the world use a BSP style thread. Download 41 Suburban Water Heater PDF manuals. Troubleshoot issues such as ⦠This document doesn’t specifically cover the Atwood design. The Suburban Advantage line of RV water heaters includes high recovery gas, gas/electric combination, gas/electric/motor aid and tankless, continuous models with sizes and features to match the requirements of almost any RV. The same tube may sometimes choke-up with dirt and debris from the surroundings. Bangs, pops and gurgling sounds can be caused simply by the expanding and contracting of metal parts. Page 4 water tank. The heater requires at least 12 volts of electricity to be supplied at all times, to both its circuit board as well as the gas valves present on it to keep the device running. Sometimes when you have not used your heater in some time, it can collect up a lot of air in its insides. Although, one simple method to get rid of this air is to try lighting up the furnace a few more times. Use a voltmeter or purchase one to check the voltage coming to it. Do you know where to look and how to fix it? When camping out in the wild with an RV on your side, having a bath in hot water is a pleasure beyond words. This is increased in older hot water units as mineral and hard water builds up on the inside of the tank. I first noticed it when I was sitting outside and it attempeted to light and I heard the igniter clicking like crazy and then stopped. A Suburban vent cap must be installed on the unit and all side inspection panels must be in place for proper water heater operation. All Rights Reserved. No Hot Water. It is a little rocker switch located inside the external access panel at the bottom left-hand corner. Complete a combustion test and replace the water heater (if it fails) with a Suburban Nautilus instantaneous (gas only) water heater or an equivalent competitive model. These are the three major causes behind why suburban RV hot water heater won’t light. This happens on both mains water and caravan ⦠Solution: All you need to do is; unplug the RV hot heater plug from the electric board, and then plug it again, making a tight connection. Eureka Apex 2 vs Eureka Apex 2XT- Which One? It shows the parts of the circuit as simplified forms, and the power as well as signal links in between the gadgets. Water Heater Troubleshooting.pdf Page | 1 Version: 1.1 March 8, 2013 Water Heater Troubleshooting & Repair (Suburban) This guide is intended to assist Heartland Owners in troubleshooting and repairing common failures of the Suburban Water Heater. Close the gas isolation valve to the hot water system itself 3. 1. Bass Pro Tents Review 2021- Are They Good? Kisae Inverter Review 2021- Should You Use It. The suburban RV hot water heater ticks all the right boxes of what you would want in this kind of appliance. Considering this, water heaters are a great option. A lot of his work was published on well-known travel magazines like: Travel+Leisure, Thrillist. Video 02: Pressure Relief Valve Function. Suburban is a brand that always delivers quality products, such as its line of RV water heaters. Solution: You would have to bleed the air out when Suburban RV hot water heater won’t light. The Suburban RV Water Heater comes in both six and 10 gallon porcelain-lined steel tanks. 14. Currently working as a blogger, he takes pride in providing comprehensive contents about camping knowledge, survival skills based on his own experience. White Gas vs Propane For Camping- What’s The Better Option? $14.14 $ 14. Hot Water Problem #5: Your hot water system makes strange noises. Do not use the hot water system until the situation is resolved 4. Video 05: Odor Elminiation Cut and paste from RV Daily, The issue with the popular Suburban Hot Water System licence suspension continues. Before trying to inspect the anode make sure your Hot Water System has been turned off long enough to cool down. The Suburban RV Water Heater comes in both six and 10 gallon porcelain-lined steel tanks. This is increased in older hot water units as mineral and hard water builds up on the inside of the tank. It is a facility that makes you feel homey and relaxed. One simple fix for this is you can manually light up the heater after turning the gas up. These can be used to heat up the water for your use when you are in cold areas. The other morning while breaking camp to head out to the next destination I noticed the electrical on/off switch for my Suburban SW6DE Water Heater was a little stiff and it required a lot of force to turn it off. Page 7 However, some people using the Suburban RV hot water heater have run into the problem that it won’t light up. You can claim your warranty to get your ignitor replaced. The water heaters have up-front controls and push-button lighting. Suburban hot water systems are a tank type design by which an element or gas pilot light will keep the water in your Suburban Hot Water System tank at a constant temperature. It works great on electric. If it does not work, you would have to check the wiring of the water heater and the connection of the PC board. The Suburban range of HWSs are made in the USA and they use the NPT style thread for the anode. Video 03: Bypass Valve Systems. Also, make sure that you have enough gas in your tank and it not running out. The blocked passage hinders propane from getting to the igniter. Suburban hot water system. 3) Turn off the 12 volt pump. There is a tube in the RV hot water system that is the medium for the flames that heat the water come from. Purging the heater tank is the perfect solution for getting rid of air intrusions. The circuit of the heater is attached to an ignitor. In case, the hot heater starts, you could conclude that air entrance is causing the real issue.